3410 NE 5th Avenue, Oakland Park, Florida 33334
MATERIAL SAFETY DATA SHEETPRIVATE
DATE OF PREPARATION: May 29, 1997 EMERGENCY TELEPHONE #: (305) 565-8475
AFTER HOURS 800-424-9300
SECTION I PRODUCT IDENTIFICATION
Product Name: PUNCHIII MICRO BUBBLE TRAINING
Product Class: Self Defense Spray, Aerosol
D.O.T. Shipping Class: ORM-D Consumer Commodity
SECTION II HAZARDOUS INGREDIENTS
INGREDIENT PERCENT EXPOSURE LIMITS VAPOR PRESSURE
WATER N/A N/A
ISOPROPYL ALCOHOL 400 PPM 400 PPM 33.0 MMHG
POLYSORBAC 80 AS FOAM AGENT None Established Not Found
DYMEL 134A AS PROPELLANT 7% 1000 PPM 1000PPM 96 psg @ 77oF
SECTION III PHYSICAL DATA
Boiling Range: 180o F
Vapor Density: 2.1 (air=1) Heavier than air
Percentage Volatile by weight: 100%
Evaporation Rate: 1.7 (Butyl Acetate=1)
Weight per gallon: 7.5 lbs.
Specific Gravity: 0.90 @ 60o F
Appearance: Clear Liquid
Odor: Slight Alcohol odor may also be present.
SECTION IV FIRE AND SAFETY EXPLOSION HAZARD DATA
Flammability Classification OSHA: Non-Flammable
Shipping Classification D.O.T.: ORM-D
Flash Point: 130o F
Flammable Levels in Air: Lower: >2.5 Upper: 12.0
Extinguishing Media: Foam, Water, CO2, Dry Chemical
Unusual Fire and Explosion Hazards: Do not expose to heat or flame or store above 120o F as high internal pressures may cause leaking.
Special Fire Fighting Procedures: Full protective equipment including self contained breathing apparatus should be used, Fog nozzles should be used to cool closed containers to prevent pressure buildup. Move undamaged containers from fire area if accomplished without risk.
SECTION V HEALTH HAZARD DATA
PRIMARY ROUTE (S) OF ENTRY: Dermal, Inhalation
EMERGENCY AND FIRST AID PROCEDURE:
EYES: Flush eyes with large quantities of water to speed recovery. Face subject into wind or forced air source such as fans or air conditioning outlet.
SKIN CONTACT: Wash affected area with soap and water to avoid transfer to more sensitive areas. Only minor sensation with skin contact in most areas.
INHALATION: Minor respiratory stimulation.
INGESTION: Severe burning heartburn sensation may cause nausea.
PHYSIOLOGICAL EFFECTS AND HEALTH INFORMATION
EYE EFFECTS:This product is a minor eye irritant, Tearing and redness may occur.
This product has been thoroughly tested by FDA approved Labs and has been found to have minor non persistent eye irritation, to be non toxic, and not to cause dermatitis.
SECTION VI REACTIVITY DATA
HAZARDOUS POLYMERIZATION: Will Not Occur
CONDITIONS TO AVOID: Heat, open flames, electrical and static discharges.
INCOMPATIBILITY (MATERIALS TO AVOID): Strong Acids, Alkalies and Oxidizers.
SECTION VII SPILL OR LEAK PROCEDURES
STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED: Ventilate area. Remove all possible sources of ignition. Avoid prolonged breathing of vapors. Confine spill with inert absorbent. Wear protective equipment during clean up.
WASTE DISPOSAL: Incinerate in an approved incinerator or dispose of in accordance with Local, State and Federal Regulations.
SECTION VIII SAFE HANDLING AND USE INFORMATION
RESPIRATORY PROTECTION: Use NIOSH/MSHA approved Chemical/Mechanical type filter system to remove a combination or particles, gas & vapor. Use air line if necessary.
VENTILATION: Use adequate ventilation in volume and pattern to keep LEL and TLV's in Section II below recommended level to produce explosion or fire. General mechanical ventilation should comply with OSHA 1910.94.
PROTECTIVE GLOVES: Use rubber gloves.
EYE PROTECTION: Safety glasses or goggles with splash guards or side shields.
OTHER PROTECTIVE EQUIPMENT: Prevent prolonged skin contact to contaminated clothing.
SECTION IX SPECIAL PRECAUTIONS
PRECAUTIONS TO BE TAKEN IN HANDLING AND STORING: Store in a cool dry area away from sources of ignition. When storing large quantities, store in building designed and protected against fire.
DO NOT STORE IN DIRECT SUNLIGHT OR ABOVE 120O F.
OTHER PRECAUTIONS: "FOR INDUSTRIAL USE ONLY" Do not take internally. If ingested, DO NOT INDUCE VOMITING. Consult a physician.
THE INFORMATION CONTAINED HEREIN IS BASED ON TECHNICAL DATA WHICH WE BELIEVE TO BE RELIABLE, HOWEVER, SINCE THE CONDITIONS UNDER WHICH THIS INFORMATION MAY BE APPLIED ARE BEYOND OUR CONTROL WE CAN ASSUME NO LIABILITY FOR RESULTS OF ITS APPLICATION. THIS INFORMATION SHOULD BE USED ONLY BY PERSONS HAVING SUFFICIENT TECHNICAL SKILL TO MAKE INFORMED JUDGEMENTS REGARDING ITS APPLICATION.